Influencing factors of reducing gas in water wall area of a 600 MW unit boiler

XUE Xiaolei; YU Shengjie; CHEN Min; WANG Xiaohua

English

您当前的位置：

首页 >

文章列表页 >

Influencing factors of reducing gas in water wall area of a 600 MW unit boiler

Thermal Power Generation Vol. 45, Issue 12, Pages: 95-102(2016)

更新时间：2025-09-28

- Influencing factors of reducing gas in water wall area of a 600 MW unit boiler
- 作者机构：
  
  西安热工研究院有限公司苏州分公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TM621.2
- Published：2016
- 稿件说明：
移动端阅览
XUE Xiaolei, YU Shengjie, CHEN Min, et al. Influencing factors of reducing gas in water wall area of a 600 MW unit boiler[J]. Thermal Power Generation, 2016, 45(12): 95-102.
DOI：

XUE Xiaolei, YU Shengjie, CHEN Min, et al. Influencing factors of reducing gas in water wall area of a 600 MW unit boiler[J]. Thermal Power Generation, 2016, 45(12): 95-102. DOI：

摘要

针对某电厂600MW机组锅炉水冷壁区域存在严重高温腐蚀的问题

通过试验研究了配风方式、运行氧量等因素对水冷壁区域还原性气氛的影响。结果表明:600 MW负荷常规运行方式下

锅炉水冷壁区域还原性气体体积分数较高

CO体积分数为10 000~30 000μL/L

H_2S体积分数为80~130μL/L;与高负荷工况相比

中低负荷工况下

锅炉水冷壁近壁处的还原性气体体积分数下降明显;随着燃尽风风门挡板开度的减小

锅炉水冷壁近壁处烟气中CO体积分数明显降低;随着运行氧量的提高

锅炉水冷壁近壁处的还原性气体体积分数均有不同程度的降低

但下降幅度较小;相对于其他磨煤机运行方式

停中间磨煤机运行工况下

锅炉水冷壁区域还原性气体体积分数整体较低;煤中硫分的升高会使炉膛水冷壁区域H_2S体积分数明显上升

建议尽量燃用低硫分煤种。

Abstract

Serious high temperature corrosion occurred on water wall area of a 600 MW unit boiler.To solve this problem

the effects of the related factors on reducing atmosphere

such as the operation oxygen content and air distribution methods

were investigated.The results show that

the concentration of reducing gas around the boiler water wall area was higher under normal operating mode with 600 MW load condition

of which the volume fraction of CO was about 10 000~30 000μL/L

and that of H_2 S was about 80~130μL/L.Compared with the high-load conditions

the concentration of reducing gas around the boiler water wall area decreased more significantly under low load conditions.With a decrease in air damper opening of over-fire air

the volume fraction of CO in water wall area of the boiler declined obviously.With an increase in the operation oxygen content

the concentration of reducing gas around the boiler water wall area decreased slightly.Compared with other operation modes of the mills

the overall concentration of reducing gas in the boiler wall area is low under conditions with intermediate mill outages.High sulfur content in the coal resulted in an obvious increase in volume fraction of H_2 S in boiler water wall area.It is recommended to burn low-sulfur coal.

关键词

Keywords

references

Views

264

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

TEST STUDY ON COMBUSTION ADJUSTMENT OF BOILER FOR SUPERCRITICAL 600MW UNIT IN YANGZHOU POWER PLANT

APPLICATION OF PSO IN NO_x EMISSION FROM BOILER

OXYGEN CONTENT CONTROL FOR A BOILER IN ULTRA SUPERCRITICAL 600 MW UNIT

Operation adjustment for high temperature corrosion in water wall of supercritical opposed firing boiler

Research on influence of water wall adhering wind dip angle on high temperature corrosion in tangentially-fired boiler burning high sulfur coal

Related Author

JIANG Jian-gang1

LI Yong-ling1

ZHANG Chun-fa21.Department of Power

FAN Rongrong1

YAO Cuilan2

YANG Jusheng1

ZHANG Yongfa3

XIE Kechang3 1.College of Electrical and Power Engineering

Related Institution

Power Department of Baoding Electric Power Vocational and Technical College

Department of Power Engineering, North China Electric Power University

School of Electrical and Power Engineering, Taiyuan University of Technology

Shanxi Electric Power Vocational and Technical College

Taiyuan University of Technology Coal Science and Technology Ministry of Education and Key Laboratory of Shanxi Province

AI问答

⁰