Automatic control and protection logic for evaporation treatment of desulfurization wastewater in thermal power plants

GUO Jun; BIE Xuan; JIA Shaoguang; WU Yang; CHAI Jin; MA Shuangchen

English

您当前的位置：

首页 >

文章列表页 >

Automatic control and protection logic for evaporation treatment of desulfurization wastewater in thermal power plants

Thermal Power Generation Vol. 45, Issue 9, Pages: 100-104(2016)

更新时间：2025-09-28

- Automatic control and protection logic for evaporation treatment of desulfurization wastewater in thermal power plants
- 作者机构：
  
  1. 河北省电力勘测设计研究院
  2. 华北电力大学(保定)环境学院
- 作者简介：
- 基金信息：
- DOI：
  CLC： X773
- Published：2016
- 稿件说明：
移动端阅览
GUO Jun, BIE Xuan, JIA Shaoguang, et al. Automatic control and protection logic for evaporation treatment of desulfurization wastewater in thermal power plants[J]. Thermal Power Generation, 2016, 45(9): 100-104.
DOI：

GUO Jun, BIE Xuan, JIA Shaoguang, et al. Automatic control and protection logic for evaporation treatment of desulfurization wastewater in thermal power plants[J]. Thermal Power Generation, 2016, 45(9): 100-104. DOI：

摘要

为实现电厂脱硫废水零排放智能控制

本文提出一种采用自动控制与保护逻辑的脱硫废水蒸发处理方法

利用抽取空气预热器前、后烟气管道中烟气的热能对脱硫废水进行蒸发处理。该控制系统为一个带有前馈控制的串级控制系统

前馈控制通过对空气预热器前、后烟气抽出管道上阀门初始开度的确定

控制除尘器入口烟气温度在合理范围内

串级控制保证整个系统稳定运行

同时设计了相应的保护逻辑。该控制系统能大幅降低运行操作的复杂程度

减少人为误操作的风险

有利于脱硫废水蒸发系统的稳定经济运行。

Abstract

To realize intelligent control for zero discharge of flue gas desulfurization(FGD)wastewater in thermal power plants

this paper proposed a FGD waste water evaporation treatment method using automatic control and protection logic.This method takes use of the thermal energy of the flue gas in front of and behind the air pre-heater(AHP)to carry out evaporation treatment of the desulfurization waste water.This control system is a cascade control system with a feedforward control.The feedforward control keeps the flue gas temperature of at the electrostatic precipitator(ESP)inlet in a suitable range by controlling the initial opening degree of the valves on the pipes in front of and behind the AHP.The cascade control system ensures a long-term stable operation of the whole system.Moreover

the corresponding protection logic is designed.This control system can significantly reduce the complexity of the operation and reduce the risk of human mistakes

which is conducive to the stable and economical operation of the FGD wastewater evaporation system.

关键词

Keywords

references

Views

183

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

DEVELOPMENT AND APPLICATION OF ELECTRIC ACTUATOR IN THE AUTOMATIC CONTROL SYSTEMS

BED-OVERTURN PHENOMENON OF UNDERPANTS LEG IN 300 MW CFB BOILER AND REMEDIAL METHOD THEREOF

CALCULATION OF WASTEWATER AMOUNT FOR FGD SYSTEM AND ITS ZERO DISCHARGE TECHNOLOGY

ANALYSIS OF HEAVY METAL CONTENT IN WASTEWATER AND SLUDGE FROM FGD SYSTEM OF COAL-FIRED POWER PLANTS

OPTIMIZATION OF AUTOMATIC CONTROL STRATEGY UNDER ABNORMAL OPERATING CONDITIONS OF SUBCRITICAL UNITS

Related Author

HE Zeng-yao~1

GAO Wen-yan~2(1.Guohua Ninghai Power Plant

WU Yu-ping

ZHOU Si-lin

JIANG Mao-qingSichuan Baima CFB Demonstration Power Plant Co Ltd

ZHOU Chen1

TAN Wen-yi21.Zhejiang Electric Power Testing & Research Institute

WANG Jing1

Related Institution

Beijing Litong High tech Development Co., Ltd

Guohua Ninghai Power Plant

Baima Circulating Fluidized Bed Demonstration Power Station Co., Ltd

Department of Environmental Engineering, Nanjing University of Engineering

Zhejiang Electric Power Test and Research Institute

AI问答

⁰