Experimental investigation on two-phase flow instability of ultra supercritical pressure boiler with spirally water wall tubes

WANG Siyang; MAO Kaiyuan; LONG Jun; WANG Wenyu; YANG Dong; BI Qincheng

English

您当前的位置：

首页 >

文章列表页 >

Experimental investigation on two-phase flow instability of ultra supercritical pressure boiler with spirally water wall tubes

Thermal Power Generation Vol. 45, Issue 2, Pages: 16-21(2016)

更新时间：2025-09-28

- Experimental investigation on two-phase flow instability of ultra supercritical pressure boiler with spirally water wall tubes
- 作者机构：
  
  西安交通大学动力工程多相流国家重点实验室
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK229.2
- Published：2016
- 稿件说明：
移动端阅览
WANG Siyang, MAO Kaiyuan, LONG Jun, et al. Experimental investigation on two-phase flow instability of ultra supercritical pressure boiler with spirally water wall tubes[J]. Thermal Power Generation, 2016, 45(2): 16-21.
DOI：

WANG Siyang, MAO Kaiyuan, LONG Jun, et al. Experimental investigation on two-phase flow instability of ultra supercritical pressure boiler with spirally water wall tubes[J]. Thermal Power Generation, 2016, 45(2): 16-21. DOI：

摘要

针对某超超临界1 000 MW机组锅炉螺旋管圈水冷壁设计方案

对水平倾角20°的光管内汽水两相流动不稳定性进行了试验研究

重点分析了压力降脉动和密度波脉动发生的边界条件和可压缩容积、压力、质量流率等参数对脉动的影响规律。结果表明:上述系统参数对2种脉动的界限热流密度的影响具有较好的规律性

与已有文献报道一致

但部分参数对界限含汽率的影响则因试验条件而异;低过冷度下的光管内压力降脉动的界限热流密度大于高过冷度下的内螺纹管内压力降脉动的界限热流密度;根据试验结果

得到了压力降脉动和密度波脉动在不同系统参数条件下界限热流密度及界限含汽率的变化范围和脉动起始点关系式。

Abstract

For the design of an ultra supercritical 1 000 MW unit boiler with spirally water wall tubes

an experiment was conducted on the instability of the steam-water two-phase flow inside a smooth tube with an inclined angle of 20 from the horizon.The boundary conditions about the occurrence of the pressure drop oscillations and the density wave oscillations were discussed.The effects of the compressible volume

pressure and mass flux were primarily analyzed.The results show that the above parameters show regular influences on the boundary heat flux for the mentioned two oscillations

which are accordant with existed experimental conclusions

but some of them displays variable influence

which depends on the experimental operation conditions

on the boundary dryness.The boundary heat flux of the pressure drop oscillations in the test smooth tube at low sub-cooling can be higher than that in the rifled tube at high sub-cooling.Under variable system parameter conditions

the variation range of boundary heat flux as well as boundary dryness was derived and the empirical correlations on oscillation initial point for the pressure drop oscillations and the density wave oscillations were obtained.

关键词

Keywords

references

Views

200

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Water wall temperature deviation of an ultra-supercritical 1 000 MW unit boiler: analysis and countermeasures

Computational analysis on hydrodynamic characteristics and flow instability of an ultra supercritical 1 000 MW double-reheat unit boiler

CAUSE ANALYSIS OF WATER-WALL TUBE BURST AND LEAKAGE FOR A 2100t/h BOILER

STUDY ON HIGH-TEMPERATURE CORROSION OF WATER-WALL IN UTILITY BOILER AND PREVENTION THEREOF

ONE DIMENTIONAL HEAT FLUX DISTRIBUTION CHARACTERS IN LOWER FURNACE OF BOILERS WITH WET BOTTOM

Related Author

ZHANG Shihong

LIU Zhengqiang

NIE Xin

YUN Panfeng

XIE Haiyan

WANG Fengjun

HUANG Ying

HE Wang-fei

Related Institution

State Power Investment Corporation Henan Electric Power Co., Ltd. Technical Information Center

State Power Investment Corporation Henan Electric Power Co., Ltd. Pingdingshan Power Generation Branch

Xi'an Thermal Power Research Institute Co., Ltd

State Key Laboratory of Efficient and Clean Coal fired Power Plant Boiler of Harbin Boiler Works Co., Ltd

Shajiao C Power Plant

AI问答

⁰