Kinetic mechanism of sulfation of condensed sodium chlorides

SANG Qianlian; HU Zhongfa; ZHANG Lan; LI Yan; LI Wenguang; WANG Xuebin

English

您当前的位置：

首页 >

文章列表页 >

Kinetic mechanism of sulfation of condensed sodium chlorides

Thermal Power Generation Vol. 44, Issue 10, Pages: 41-45(2015)

更新时间：2025-09-28

- Kinetic mechanism of sulfation of condensed sodium chlorides
- 作者机构：
  
  1. 河南省锅炉压力容器安全检测研究院
  2. 西安交通大学热流科学与工程教育部重点实验室
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK16
- Published：2015
- 稿件说明：
移动端阅览
SANG Qianlian, HU Zhongfa, ZHANG Lan, et al. Kinetic mechanism of sulfation of condensed sodium chlorides[J]. Thermal Power Generation, 2015, 44(10): 41-45.
DOI：

SANG Qianlian, HU Zhongfa, ZHANG Lan, et al. Kinetic mechanism of sulfation of condensed sodium chlorides[J]. Thermal Power Generation, 2015, 44(10): 41-45. DOI：

摘要

为了解碱金属氯化物的硫酸化动力学机理

利用固定床研究了反应温度及反应气体SO2

O2和H2O的体积分数对NaCl异相硫酸化率的影响

并采用X射线衍射仪对试样中元素进行分析。结果表明:NaCl异相硫酸化反应产物为Na2SO4;气体SO2

O2和H2O的体积分数的增加均可促进NaCl异相硫酸化;当反应温度低于773K时

活化能为12kJ/mol

此时温度变化对NaCl异相硫酸化率没有显著影响

当反应温度高于773K时

活化能为92kJ/mol

此时NaCl异相硫酸化率随温度升高呈指数增加;同时NaCl异相硫酸化高、低温反应机理不同

可能是由于高温下会形成共熔体引起的。

Abstract

Sulfation of alkali chlorides has great significance on relieving slagging and corrosion on heating surfaces of the boiler during combustion of alkali-and chloride-rich fuels.On a fixed bed

this paper experimentally investigated the effects of sulfation temperature and reactants(like SO2

O2 and H2O)concentration on the heterogeneous sulfation of NaCl.The products were analyzed by the X-ray diffractometer.The results show that

only Na2SO4 was found in the products.The increase in volume fraction of SO2

O2 and H2O enhanced the sulfation ratio of NaCl.At temperatures below 773 K

the activation energy of the sulfation reaction was 12kJ/mol

indicating the sulfation ratio of NaCl changed little at low temperatures.However

at temperatures above 773 K

the activation energy of the sulfation reaction was 92kJ/mol

and the sulfation rate of NaCl exhibited an exponential growth with the temperature.The sulfation mechanism of NaCl at high and low temperatures was different

may be it is caused by formation of the eutectic at high temperatures.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Chemical looping combustion characteristics and kinetics study of anthracite with CoO oxygen carrier

Isothermal study of gasification process of biomass char and coal char in CO₂ atmosphere

Study on adsorption properties and adsorption kinetics of resin-based air carbon capture adsorbents

Research progress on ammonia-blended natural gas combustion

Softening experiment on ion exchange of residual Ca (II) from high salinity wastewater

Related Author

WANG Baowen

ZHANG Mengzhu

XU Qi

ZHANG Jianliang

GENG Weiwei

ZUO Haibin

WANG Guangwei

徐党旗

Related Institution

School of Electric Power, North China University of Water Resources and Electric Power

State Key Laboratory of New Technology for Iron and Steel Metallurgy, University of Science and Technology Beijing

School of Metallurgy and Ecological Engineering, Beijing University of Science and Technology

School of Power and Mechanical Engineering, Wuhan University

Liaoning Key Laboratory of Clean Energy, Shenyang Institute of Aeronautics and Astronautics

AI问答

⁰