Eddy-dissipation model based numerical simulation on co-combustion characteristics of a coal-fired boiler co-firing with different kinds of sludge

ZHU Tianyu; YIN Libao; ZHANG Cheng; FANG Qingyan; XU Qisheng; CHEN Gang

English

您当前的位置：

首页 >

文章列表页 >

Eddy-dissipation model based numerical simulation on co-combustion characteristics of a coal-fired boiler co-firing with different kinds of sludge

Thermal Power Generation Vol. 44, Issue 6, Pages: 1-9(2015)

更新时间：2025-09-28

- Eddy-dissipation model based numerical simulation on co-combustion characteristics of a coal-fired boiler co-firing with different kinds of sludge
- 作者机构：
  
  1. 华中科技大学煤燃烧国家重点实验室
  2. 广东电网公司电力科学研究院
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK229.6
- Published：2015
- 稿件说明：
移动端阅览
ZHU Tianyu, YIN Libao, ZHANG Cheng, et al. Eddy-dissipation model based numerical simulation on co-combustion characteristics of a coal-fired boiler co-firing with different kinds of sludge[J]. Thermal Power Generation, 2015, 44(6): 1-9.
DOI：

ZHU Tianyu, YIN Libao, ZHANG Cheng, et al. Eddy-dissipation model based numerical simulation on co-combustion characteristics of a coal-fired boiler co-firing with different kinds of sludge[J]. Thermal Power Generation, 2015, 44(6): 1-9. DOI：

摘要

对某台420t/h四角切圆燃煤锅炉进行了单煤燃烧和2种污泥在不同含水率和质量配比下的掺烧数值模拟研究。采用涡耗散模型(EDM)模拟气相湍流燃烧

研究多工况下的炉内流动、燃烧、污染物排放和燃料总燃尽率、煤粉颗粒燃尽率等。结果表明:EDM能较好地模拟污泥配比和含水率对锅炉燃烧及污染物排放特性的影响;随着掺混比和污泥含水率的增加

水蒸气吸热造成炉膛整体温度水平下降

且燃料总燃尽率呈下降趋势;掺烧污泥后

由于燃料型NOx生成量的减少

锅炉总NOx排放质量浓度明显呈下降趋势;由于不同污泥中硫含量各异

2种污泥掺烧后锅炉SO2排放特性差异较大。

Abstract

Taking a 420t/h tangentially coal-fired boiler as the object

numerical simulation using eddy-dissipation model(EDM)was carried out to evaluate the combustion characteristics of pure coal and mixtures of coal and sludge with different moisture contents and mass ratios.Several parameters under various operation conditions were investigated

such as the flow field

combustion

pollutants emission characteristics

total fuel burn out rate and coal particle burnout rate during the gas phase turbulent co-combustion.The results show that

the EDM can reasonably simulate the effects of mass ratio and moisture content of sludge on the combustion characteristics and pollutants emissions after co-firing.With the increasing mass ratio and moisture content of sludge

the vapor absorbed the heat

causing a decrease in furnace temperature

thus the total fuel burn out rate decreased.After the sludge was co-fired

the formation of fuel-NOx reduced

leading to an significant reduction in total NOx emission.The SO2 emission characteristics were obviously different in co-combustion of different kinds of sludge.This is mainly because the sulfur content in different kinds of sludge varies from each other.

关键词

Keywords

references

Views

470

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Co-combustion of sludge in a 100 MW unit coal-fired boiler: numerical simulation

Numerical study on combustion characteristics of a tangentially fired pulverized-coal boiler in O2/CO2 atmosphere

THERMOGRAVIMETRIC STUDY ON BASIC CHARACTERISTICS OF SEWAGE SLUDGE AND IT’S MIXBURNING PERFORMANCE WITH COAL

RESEARCH ON CO-INCINERATION TECHNOLOGY OF MUNICIPAL SOLID WASTES AND COAL IN CHINA

Experimental and numerical simulation study on slagging characteristics of multiple fuels co-combustion in a 1 000 MW double-swirl coal-fired boiler

Related Author

ZHU Tianyu

JI Haimin

XU Dangqi

LI Hongzhi

ZHAO Zhiping

XUE Ning

ZHOU Fei

NIE Jianping

Related Institution

Xi'an Thermal Power Research Institute Co.,Ltd.

Huazhong University of Science and Technology

Beijing Boqi Electric Power Technology Co., Ltd

State Key Laboratory of Clean Energy Utilization, Zhejiang University

AI问答

⁰