Reason analysis and treatment for vibration in a supercritical unit tower type boiler

BIAN Fang; ZHANG Yugang; WANG Huaiyong; YANG Zhiyu; CAO Handing

English

您当前的位置：

首页 >

文章列表页 >

Reason analysis and treatment for vibration in a supercritical unit tower type boiler

Thermal Power Generation Vol. 44, Issue 5, Pages: 113-117(2015)

更新时间：2025-09-28

- Reason analysis and treatment for vibration in a supercritical unit tower type boiler
- 作者机构：
  
  华能吉林发电有限公司九台电厂
- 作者简介：
- 基金信息：
- DOI：
  CLC： TM621.2
- Published：2015
- 稿件说明：
移动端阅览
BIAN Fang, ZHANG Yugang, WANG Huaiyong, et al. Reason analysis and treatment for vibration in a supercritical unit tower type boiler[J]. Thermal Power Generation, 2015, 44(5): 113-117.
DOI：

BIAN Fang, ZHANG Yugang, WANG Huaiyong, et al. Reason analysis and treatment for vibration in a supercritical unit tower type boiler[J]. Thermal Power Generation, 2015, 44(5): 113-117. DOI：

摘要

华能九台电厂2台600MW级燃烧褐煤的超临界塔式锅炉在高负荷工况下

锅炉本体上部及尾部烟道均存在高频振动问题

造成受热面频繁泄漏。分析认为

锅炉振动是由发生在锅炉受热面管子的卡门涡流脱落引起的脱落涡振频率与发生在锅炉烟室的声学驻波频率产生共振所致。对此

提出了在烟道内加装隔板

通过改变烟室的声学驻波频率来消除共振。该方案实施后

不仅彻底消除了锅炉振动

而且未再发生末级过热器壁温大面积超限等不良现象

改造效果良好。

Abstract

High frequency vibration occurred in upper part and tail flue duct of the 600 MW supercritical unit tower type boiler firing lignite in Huaneng Jiutai Power Plant

resulting in frequent heat leakage of heat surface.Analysis shows the major reason is the sympathetic vibration between the vortex shedding frequency resulted from the Karman vortex shedding from the heating surface and the acoustic standing wave frequency occurred in gas room.Therefore

to eliminate the sympathetic vibration by changing the acoustic standing wave frequency in gas room

a countermeasure that adding baffles in the flue duct was proposed.After the baffles were added

the boiler vibration was thoroughly eliminated.Moreover

over temperature of the final super heater tube wall with large area never occurred again.

关键词

Keywords

references

Views

121

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Optimization and reconstruction of superheater and reheater for a 1 000 MW tower type boiler with double-reheat cycle

Vibration analysis of axial flow fan for large capacity unit

Comparative analysis of calculation standards for pipe hanger interval

Flexuous vibration characteristics of HP/IP rotor in a 1 000 MW nuclear power unit

Study on installation of high-temperature heat exchanger for a 1 100 t/h tower type boiler

Related Author

LIU Chao

LIU Hui

WANG Lin

GAO Jinghui

ZHAO Zhidan

WANG Hongyu

MENG Yingqi

HE Xiaofeng

Related Institution

Xi’an Thermal Power Research Institute Co., Ltd.

Jiangsu Frontier Electric Technologies Co.,Ltd.

Northwest Electric Power Design Institute

Fujian Ningde Nuclear Power Co,.Ltd.

Xi'an Thermal Power Research Institute Co.,Ltd.

AI问答

⁰