Numerical simulation and experimental study on volatiles release during lignite drying process

LYU Tai; ZHANG Zhiyuan

English

您当前的位置：

首页 >

文章列表页 >

Numerical simulation and experimental study on volatiles release during lignite drying process

Thermal Power Generation Vol. 43, Issue 9, Pages: 65-70(2014)

更新时间：2025-09-28

- Numerical simulation and experimental study on volatiles release during lignite drying process
- 作者机构：
  
  东北电力大学能源与动力工程学院
- 作者简介：
- 基金信息：
- DOI：
  CLC： TQ533
- Published：2014
- 稿件说明：
移动端阅览
LYU Tai, ZHANG Zhiyuan. Numerical simulation and experimental study on volatiles release during lignite drying process[J]. Thermal Power Generation, 2014, 43(9): 65-70.
DOI：

LYU Tai, ZHANG Zhiyuan. Numerical simulation and experimental study on volatiles release during lignite drying process[J]. Thermal Power Generation, 2014, 43(9): 65-70. DOI：

摘要

通过数值模拟的方法

研究传统风扇磨煤机直吹式制粉系统下降干燥管内炉烟干燥褐煤过程中挥发分析出的情况

并通过现场采集干燥介质混合室出口、风扇磨煤机入口、风扇磨煤机出口处的气体进行色谱分析比对。结果表明:在恶劣的干燥环境下

才会有极少量的褐煤达到挥发分析出温度;在正常运行工况下

在色谱分析仪检测范围内

并没有检测到挥发分气体的产生。因此

将传统的风扇磨煤机直吹式系统改造为采用炉烟干燥的水回收风扇磨煤机仓储式制粉系统是安全可行的。

Abstract

By numerical simulation

the volatiles release during lignite drying process(dried by flue gas)in decline drying tube of the conventional fan mill pulverizing system was investigated.The results indicate that

only in relatively harsh dry conditions

a very small amount of lignite would reach the volatiles release temperature.Moreover

field tests were performed to collect the gas from dry medium mixing chamber outlet and fan mill entrance and outlet.Then chromatographic analysis was conducted for the collected gas.Comparison between the chromatographic analysis results and the simulation results shows that

under normal operation conditions and within the chromatographic analyzer's detection range

no volatile gas was detected.Therefore

transformation of the conventional direct-fired fan mill pulverizing system into open pulverizing system with flue gas drying and water recovery is completely safe and feasible.

关键词

Keywords

references

Views

108

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Application of ignition performance evaluation indicator of semi-coke in utility boilers

Temperature independent control for direct-firing pulverizing system

Experimental study on ignition temperature of coupling system of low-concentration gas and pulverized coal

Operation optimization for octagonal corner tangentially-fired boiler burning low heat value lignite coal

IMPROVEMENT OF RB CONTROL FOR DIRECT FIRING BOILER EQUIPED WITH BLOWER COAL PULVERIZED

Related Author

YAO Wei

WANG Zhichao

LIU Jiali

YANG Zhongcan

WANG Huajian

BAI Peng

YAN Xianglin

ZHOU Hongguang

Related Institution

Xi'an Thermal Power Research Institute Co.,Ltd.

Huangshi Power Plant,Huadian Corporation Hubei Branch

College of Electrical and Power Engineering, Taiyuan University of Technology

State Grid Liaoning Electric Power Science and Research Institute Co.,Ltd.

Liaoning Hongyanhe Nuclear Power Co.,Ltd.

AI问答

⁰