High temperature corrosion in wall-firing boiler:reason analysis and treatment

LIU Honggang; ZHANG Guangcai; WANG Zhigang; LIAO Xiaochun; CHEN Minsheng; CHEN Yiyang

English

您当前的位置：

首页 >

文章列表页 >

High temperature corrosion in wall-firing boiler:reason analysis and treatment

Thermal Power Generation Vol. 42, Issue 12, Pages: 129-131(2013)

更新时间：2025-09-28

- High temperature corrosion in wall-firing boiler:reason analysis and treatment
- 作者机构：
  
  1. 西安热工研究院有限公司
  2. 广东粤电靖海发电有限公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK228
- Published：2013
- 稿件说明：
移动端阅览
LIU Honggang, ZHANG Guangcai, WANG Zhigang, et al. High temperature corrosion in wall-firing boiler:reason analysis and treatment[J]. Thermal Power Generation, 2013, 42(12): 129-131.
DOI：

LIU Honggang, ZHANG Guangcai, WANG Zhigang, et al. High temperature corrosion in wall-firing boiler:reason analysis and treatment[J]. Thermal Power Generation, 2013, 42(12): 129-131. DOI：

摘要

某机组锅炉水冷壁存在高温腐蚀问题

通过试验研究与分析认为

其主要因煤粉刷墙、两侧墙附近呈强还原性气氛以及存在高浓度H2S所致。对此

通过设备改造和专项治理后

两侧墙壁面气氛良好

高温腐蚀发生的条件消除

屏式过热器与高温再热器受热面不再超温

排烟中CO浓度在100μL/L以下

设备改造前后相同试验条件下SCR入口NOx变化在20mg/m3以内。

Abstract

High temperature corrosion occurred on two sides of water wall in a boiler.Experiment showes the pulverized coal scour on water wall tube

strong reductive atmosphere near side walls and high density of H2 S are the major reasons.Thus

regulations on relative equipments were conducted.After the improvement

the atmosphere at two sides of the water wall turned well

meaning the condition that may lead to high temperature corrosion was eliminated.The temperature at platen superheater and high temperature reheater surface was no longer over high.The CO concentration in flue gas dropped below 100μL/L

and the variation of NOx concentration at inlet of the SCR was within 20mg/m3 under the same experimental conditions before and after the equipment modification.

关键词

Keywords

references

Views

316

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

CAUSE ANALYSIS OF HIGH TEMPERATURE CORROSION ON WATER WALL OF SUPERCRITICAL ONCE-THROUGH BOILERS AND COUNTERMEASURES THEREOF

Operation adjustment for high temperature corrosion in water wall of supercritical opposed firing boiler

Influencing factors of reducing gas in water wall area of a 600 MW unit boiler

Arrangement optimization for temperature measuring points on tube wall of(ultra)supercritical boilers

Experimental study on high temperature corrosion behavior of water wall materials during oxy-fuel combustion

Related Author

ZHONG Wan-li

WU Shi-deng

ZENG Fan-yun Guangdong Electric Power Science Research Institute

ZHOU Ke

SHE Yuanyuan

LU Fen

LI Jianshe

CHEN Junbin

Related Institution

Guangdong Electric Power Research Institute

Fujian Hongshan Thermal Power Co., Ltd

Xi'an Thermal Power Research Institute Co., Ltd. Suzhou Branch

Shenhua Guohua (Beijing) Electric Power Research Institute Co., Ltd

Henan Boiler and Pressure Vessel Safety Testing Research Institute

AI问答

⁰