Experimental study on low NO<sub>x</sub> combustion transformation on a 600 MW unit boiler

GAO Peng1; GAO Ming2; ZHANG Jianwen3; XIE Jianwen4 1.Shenhua Guangdong Guohua Yudean Taishan Power Generation Co.Ltd.

English

您当前的位置：

首页 >

文章列表页 >

Experimental study on low NO_x combustion transformation on a 600 MW unit boiler

Thermal Power Generation Vol. 42, Issue 4, Pages: 43-46(2013)

更新时间：2025-09-28

- Experimental study on low NO_x combustion transformation on a 600 MW unit boiler
- 作者机构：
  
  1. 广东国华粤电台山发电有限公司
  2. 东电第三工程公司
  3. 上海锅炉厂有限公司
  4. 国华电力研究院
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK223.2
- Published：2013
- 稿件说明：
移动端阅览
GAO Peng1, GAO Ming2, ZHANG Jianwen3, et al. Experimental study on low NO_x combustion transformation on a 600 MW unit boiler[J]. Thermal Power Generation, 2013, 42(4): 43-46.
DOI：

GAO Peng1, GAO Ming2, ZHANG Jianwen3, et al. Experimental study on low NO_x combustion transformation on a 600 MW unit boiler[J]. Thermal Power Generation, 2013, 42(4): 43-46. DOI：

摘要

针对台山发电公司600MW机组锅炉氮氧化物排放高的问题

提出了双分段高效复合低氮燃烧器的改造方案

并在3MW热态试验台上进行了试验研究。结果表明

采用两段SOFA运行方式比一段SOFA运行方式NOx排放值更低

与不采用空气分级的燃烧工况相比

NOx排放可以降低60%左右

而CO和飞灰含碳量的数值变化不大。目前

该公司600MW机组锅炉在燃用80%神华煤+20%石炭煤时

NOx排放值约为450mg/m3

锅炉低NOx改造后

预计NOx排放值将小于180mg/m3。

Abstract

The NOx emitted from the 600MW unit boiler of Taishan Power Plant had a high concentration.Thus

the transformation scheme for double-segment compound low NOx burner with high efficiency was proposed

and the experiment was performed on a 3 MW thermal test-bed.The results showed that

the NOx emission was lower in two-stage SOFA operation mode than in single stage SOFA operation mode.Compared with the combustion condition with no air staging

the NOx emission can be reduced by about 60%

but the concentration of CO and carbon content in fly ash had no obvious change.At present

the 600 MW unit boiler in Taishan Power Plant uses Shenhua coal(80%) and Shitan coal(20%) as the fuel

and the NOx emission is about 450 mg/m3.After the low NOx combustion transformation

the NOx emission will be lower than 180 mg/m3.

关键词

Keywords

references

Views

425

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Demonstration on scheme of low NO_x combustion combined with SCR denitrification

Experimental study on low NO_x combustion characteristics of the LNCFS burner

Experimental investigation on effect of over fire air equipping on a swirling burner on NO_x emission and burnout ratio

Influencing factors of reducing gas in water wall area of a 600 MW unit boiler

Multi-objective combustion optimization based on data mining with full-scale working condition

Related Author

LI Haibin Jiugang Power Corporation Limited

SONG Hongpeng

ZHOU Bin

ZHOU Hongmei North China Electric Power Research Institute(Xi'an) Co.

XUE Shan

HUI Shi'en

ZHOU Qulan

XUE Xiaolei

Related Institution

Shenhua Guoneng Jiugang Power Generation Co., Ltd

North China Electric Power Research Institute (Xi'an) Co., Ltd

School of Architecture and Engineering, Xi'an University of Technology

School of Energy and Power Engineering, Xi'an Jiaotong University

Xi'an Thermal Power Research Institute Co., Ltd. Suzhou Branch

AI问答

⁰

Experimental study on low NOx combustion transformation on a 600 MW unit boiler

DOI：

摘要

Abstract

关键词

Keywords

references

Experimental study on low NO_x combustion transformation on a 600 MW unit boiler