STUDY ON IRON REMOVAL PERFORMANCE OF NEW TYPE HIGH GRADIENT ELECTRO-MAGNETIC FILTER

YE Zhou; LI Nan; TIAN Wenhua; HE Huiyong Xi'an Thermal Power Research Institute Co Ltd

English

您当前的位置：

首页 >

文章列表页 >

STUDY ON IRON REMOVAL PERFORMANCE OF NEW TYPE HIGH GRADIENT ELECTRO-MAGNETIC FILTER

Thermal Power Generation Vol. 40, Issue 9, Pages: 42-44(2011)

更新时间：2025-09-28

- STUDY ON IRON REMOVAL PERFORMANCE OF NEW TYPE HIGH GRADIENT ELECTRO-MAGNETIC FILTER
- 作者机构：
  
  西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TM621.8
- Published：2011
- 稿件说明：
移动端阅览
YE Zhou, LI Nan, TIAN Wenhua, et al. STUDY ON IRON REMOVAL PERFORMANCE OF NEW TYPE HIGH GRADIENT ELECTRO-MAGNETIC FILTER[J]. Thermal Power Generation, 2011, 40(9): 42-44.
DOI：

YE Zhou, LI Nan, TIAN Wenhua, et al. STUDY ON IRON REMOVAL PERFORMANCE OF NEW TYPE HIGH GRADIENT ELECTRO-MAGNETIC FILTER[J]. Thermal Power Generation, 2011, 40(9): 42-44. DOI：

摘要

采用电厂实际铁腐蚀产物配制水样

对国产新型CAD高梯度电磁过滤器的除铁性能进行了试验。结果表明:CAD高梯度电磁过滤器以额定流量10 m3/h(流速为266 m/h)运行

当进水含铁量为20μg/L时

出水含铁量为2.5μg/L

铁去除率为86.8%

出水含铁量达到了GB/T 12145—2008《火力发电机组及蒸汽动力设备水汽质量》中超临界直流炉给水含铁量小于5μg/L的水质标准;当进水含铁量分别为40、185、700、1 500μg/L时

出水含铁量分别为7.6、12.2、18.1、26.2μg/L

铁去除率分别为81.4%、93.4%、97.4%、98.3%。CAD高梯度电磁过滤器除了可以去除铁磁性腐蚀产物

对顺磁性铁腐蚀产物的去除效率也较高。

Abstract

Adopting the water sample prepared from actual corrosion products of iron in power plants

the performance of home-made new type(CAD) high gradient electro-magnetic filter has been tested.Results show that the iron content in effluent water is 2.5 μg/L

while that in inffluent water is 20 μg/L under condition of the rated flow rate in said CAD filter being 10 m3/h(flow speed 266 m/h)

the iron removal rate is 86.8%

the iron content in effluent water reaching the water quality standard of 5μg/L iron content in feed-water of supercritical once-through boiler specified in GB/T 12145—2008 《The water-steam quality of thermal power units and steam power equipments》.In the case of iron content in inffluent water being 40

185

700

and 1500 μg/L respectively

the iron content in effluent water is 7.6

12.2

18.1

and 26.2 μg/L respectively

the iron removal rate is 81.4%

93.4%

97.4%

and 98.3% respectively.Excepting the CAD high gradient electro-magnetic filter can remove the ferromagnetic corrosion products

its removal efficiency for paramagnetic corrosion products is also higher.

关键词

Keywords

references

Views

100

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

CAUSE ANALYSIS OF ABNORMAL OUTLET-WATER TEMPERATURE FROM LOW-PRESSURE HEATER OF STEAM TURBINE NO.11 IN MA'ANSHAN POWER PLANT

TECHNICAL FEATURES OF PIPE-BLOWING ON ULTRA-SUPERCRITICAL 660 MW UNIT IN JINGGUANGSHAN POWER PLANT

STUDY ON OPTIMIZATION OF DRAIN SYSTEM FOR LOW-PRESSURE HEATER OF THE HOME-MADE 600 MW UNIT

Related Author

DING Xiao-pingMa'anshan Power Plant

FU Longlong

MA Xiaolong

XIN Junfang

ZHAO Jingtao Xi'an Thermal Power Research Institute Co Ltd

LIANG Na

ZHANG Zongheng Zhongmei Pingshuo First Gangue Power Plant

Related Institution

Ma'anshan Power Plant

Middling coal Pingshuo No.1 Gangue Power Generation Co., Ltd

AI问答

⁰