RETROFIT OF A 75 t/h PULVERRIZED COAL BOILER INTO ONE BOILER OF MIXEDLY BURNING PULVERIZED COAL AND COAL GAS

CHEN Donglin1; WEN Dazhui1; XU Huifang1; LUO Rui1; LIU Chuang1; ZHANG Peiwei2; GAO Dianqiang2; YAN Wenguang21.College of Energy and Power Engineering

English

您当前的位置：

首页 >

文章列表页 >

RETROFIT OF A 75 t/h PULVERRIZED COAL BOILER INTO ONE BOILER OF MIXEDLY BURNING PULVERIZED COAL AND COAL GAS

Thermal Power Generation Vol. 40, Issue 4, Pages: 70-73(2011)

更新时间：2025-09-28

- RETROFIT OF A 75 t/h PULVERRIZED COAL BOILER INTO ONE BOILER OF MIXEDLY BURNING PULVERIZED COAL AND COAL GAS
- 作者机构：
  
  1. 长沙理工大学能源与动力工程学院
  2. 内蒙古远兴能源公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK229.63
- Published：2011
- 稿件说明：
移动端阅览
CHEN Donglin1, WEN Dazhui1, XU Huifang1, et al. RETROFIT OF A 75 t/h PULVERRIZED COAL BOILER INTO ONE BOILER OF MIXEDLY BURNING PULVERIZED COAL AND COAL GAS[J]. Thermal Power Generation, 2011, 40(4): 70-73.
DOI：

CHEN Donglin1, WEN Dazhui1, XU Huifang1, et al. RETROFIT OF A 75 t/h PULVERRIZED COAL BOILER INTO ONE BOILER OF MIXEDLY BURNING PULVERIZED COAL AND COAL GAS[J]. Thermal Power Generation, 2011, 40(4): 70-73. DOI：

摘要

为充分利用低热值焦炉煤气

实现煤气/煤粉混合燃烧

内蒙古远兴能源公司对1台75t/h煤粉锅炉燃烧器与受热面进行了改造

即在原煤粉燃烧器下方增设了6只双通道煤气燃烧器。增设的燃烧器采用六角大切圆倾斜向下布置方式

原煤粉燃烧器喷嘴向下倾斜8~10°

增加凝渣管与省煤器面积。改后的运行与测试表明:各种燃料与负荷工况下

锅炉燃烧稳定

过热汽温正常;全烧煤气时锅炉出力可达59 t/h

排烟温度低于160℃;煤粉/煤气混烧时最大蒸汽流量可达77 t/h

排烟温度约为155℃;全烧煤粉时锅炉出力高达81 t/h

排烟温度小于147℃。

Abstract

In order to fully use the coke oven gas with low calorific value to realize mixedly burning coal gas and pulverized coal

the burners and heating surface of a 75 t/h pulverized coal(PC) boiler in Inner Mongolian Yuanxing Energy Co Ltd has been retrofitted

six gas burners with dual-passage being additionally installed below the original PC-fired burners

and tangentially arranged on a large circle and declined downward;the nozzles of original PC-fired burners being declined downward for 8~10 ℃

and the heating surface of slag-cooling tubes and economizer being increased.After retrofitting

operation and test show that the combustion is stable and the superheated steam temperature is in the normal range under all conditions of load and fuel.During the time of burning coal gas only

the output capacity of boiler can reach 59 t/h

temperature of discharged flue gas being lower than 160 ℃;in case of mixedly burning coal gas and PC

the maximum steam flow rate can reach 77 t/h

temperature of discharged flue gas being about 155 ℃;under condition of burning PC only

the output capacity of boiler being enhanced to 81 t/h

and temperature of discharged flue gas being lower than 147 ℃.

关键词

Keywords

references

Views

163

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Optimization of the mode of outlet conditions for opposed spiral firing burners

Numerical simulation of combustion process in a tangentially pulverized-coal-fired boiler under variable load operation

Experimental study on ignition delay characteristics of pulverized coal in flat flame entrained flow reactor system

Calculation method of air preheater leakage rate for boiler mixedly burning pulverized coal and blast furnace gas

Experimental investigation on ignition of low-volatile pulverized coal in a tiny- oil burner under oxygen-enriched conditions

Related Author

LI Xinhao

WANG Chunbo

GUO Yongcheng

ZOU Chan

WANG Qiuhong

WANG Chao

ZHANG Xiaotao

WANG Aijun

Related Institution

School of Energy and Power Engineering, North China Electric Power University

School of Electric Power, North China University of Water Resources and Electric Power

Xinxiang Aviation Industry (Group) Co.,Ltd.

Shandong Electric Power Engineering Consulting Institute Co.,Ltd.

Guizhou Electric Power Test and Research Institute

AI问答

⁰