AN APPROACH TO THE CAUSES LEADING TO HIGH TEMPERATURE EXHAUST FLUE GAS IN BOILER OPERATION OF SUPERCRITICAL UNIT

YAN Weiping; DONG Jinglan College of Energy and Power Engineering

English

您当前的位置：

首页 >

文章列表页 >

AN APPROACH TO THE CAUSES LEADING TO HIGH TEMPERATURE EXHAUST FLUE GAS IN BOILER OPERATION OF SUPERCRITICAL UNIT

Thermal Power Generation Vol. 39, Issue 8, Pages: 33-37(2010)

更新时间：2025-09-28

- AN APPROACH TO THE CAUSES LEADING TO HIGH TEMPERATURE EXHAUST FLUE GAS IN BOILER OPERATION OF SUPERCRITICAL UNIT
- 作者机构：
  
  华北电力大学能源与动力工程学院
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK228
- Published：2010
- 稿件说明：
移动端阅览
YAN Weiping, DONG Jinglan College of Energy and Power Engineering. AN APPROACH TO THE CAUSES LEADING TO HIGH TEMPERATURE EXHAUST FLUE GAS IN BOILER OPERATION OF SUPERCRITICAL UNIT[J]. Thermal Power Generation, 2010, 39(8): 33-37.
DOI：

YAN Weiping, DONG Jinglan College of Energy and Power Engineering. AN APPROACH TO THE CAUSES LEADING TO HIGH TEMPERATURE EXHAUST FLUE GAS IN BOILER OPERATION OF SUPERCRITICAL UNIT[J]. Thermal Power Generation, 2010, 39(8): 33-37. DOI：

摘要

我国近年来投运的部分超临界机组锅炉存在排烟温度高于设计值的现象。对部分超临界机组锅炉省煤器与空气预热器设计参数进行了分析

表明随锅炉压力与给水温度的提高

锅炉尾部需回收的热量受到制粉系统所需干燥热量的制约。采用热量与质量平衡的计算方法

对燃用不同水分与挥发分的烟煤及贫煤的两台锅炉尾部热量与制粉干燥出力进行计算。结果表明

在给水温度提高的条件下

磨煤机出口控制温度偏低、省煤器出口烟气与给水温差偏大等因素是造成锅炉排烟温度偏高的主要原因

而省煤器出口水温的进一步提高则会加剧传热恶化。

Abstract

The phenomenon of exhaust flue gas temperature being higher than the designed value exists in operation of some boilers for supercritical units put into service in recent years

the designed parameters of economizer and air preheater for some boilers of supercritical units have been analysed

it shows that the recoverable heat at the end of boiler and the heat required for drying in the coal pulverizing system were limited with increasing of the steam pressure and the feed-water temperature.By using the heat and mass balancing method

the recoverable heat at the end of boiler and the heat required for drying in coal pulverizing system have been calculated respectively for two boilers burning bituminous coal and lean coal with different water content and volatile matter content.The results of calculation show that the main causes resulting in high exhaust flue gas temperature are as follows:the controlled outlet temperature of the coal pulverizer is lower

the temperature difference between outlet flue gas and feed-water of the economizer is large etc

under condition of increasing the feed-water temperature

whereas further increasing the outlet water temperature of econimizer may intensify the deterioration of heat transfer.

关键词

Keywords

references

Views

494

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Fuzzy control system for intermediate point enthalpy based on feedforward of feed-water temperature

Simulation research on combustion performance of boiler co-firing biomass gas with coal

Boiler exhaust gas temperature modeling based on particle swarm algorithm and support vector machine

燃煤锅炉排烟温度高的原因分析及运行中可采取的措施

MEASURES AND METHODS FOR DECREASING FLUE GAS TEMPERATURE OF BOILERS

Related Author

YANG Zihao

ZHANG Yanping

GAO Wei

ZHANG Xiaotao

LIU Ying

DING Quanbin

ZHONG Yafei

WEI Hongqi

Related Institution

School of Energy and Power Engineering, Huazhong University of Science and Technology

School of Electric Power, North China University of Water Resources and Electric Power

School of Energy and Environment, Southeast University

Luohe Power Plant

Luohe Power Plant Anhui Huainan

AI问答

⁰