Operation optimization of low-low temperature economizer combined air heater system

LYU Kai; SHE Yuanyuan; ZHANG Zhixiang; WANG Dongye; YU Longwen; LIU Honggang; MA Tingshan

doi:10.19666/j.rlfd.201708090

English

您当前的位置：

首页 >

文章列表页 >

Operation optimization of low-low temperature economizer combined air heater system

Thermal Power Generation Vol. 47, Issue 6, Pages: 105-110(2018)

更新时间：2025-09-28

- Operation optimization of low-low temperature economizer combined air heater system
- 作者机构：
  
  1. 西安西热节能技术有限公司
  2. 西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201708090
  CLC： TM621.4
- Published Online：06 June 2018，
  
  Published：2018
- 稿件说明：
移动端阅览
LYU Kai, SHE Yuanyuan, ZHANG Zhixiang, et al. Operation optimization of low-low temperature economizer combined air heater system[J]. Thermal Power Generation, 2018, 47(6): 105-110.
DOI：

LYU Kai, SHE Yuanyuan, ZHANG Zhixiang, et al. Operation optimization of low-low temperature economizer combined air heater system[J]. Thermal Power Generation, 2018, 47(6): 105-110. DOI： 10.19666/j.rlfd.201708090.

摘要

为了探索不同负荷下低低温省煤器联合暖风器系统运行优化的最佳运行方式

依托某300 MW机组进行了运行优化研究。结果表明:环境空气温度基本一致

锅炉排烟温度随空气在暖风器温升呈线性增加趋势;随暖风器温升

中高负荷下暖风器热交换量占比呈近似线性增加

低负荷下呈先增高后趋于平缓的趋势;以低低温省煤器联合暖风器系统停运状态为基准

试验范围内汽轮机热耗率降低值随回收热量呈近似线性正比关系

锅炉热效率提高值随暖风器出口风温升高值呈正相关关系;试验范围内供电煤耗下降值随暖风器出口风温升高呈正相关关系

与暖风器侧吸收热量占比升高呈总体正相关关系;实际运行中控制暖风器出口风温在70℃时机组整体经济性最佳。该结果可为提高火电机组运行经济性提供一定的技术参考。

Abstract

To explore the optimum operation mode for the operation optimization of the low-temperature economizer combined heater system under different loads

operation optimization test is carried out in a 300 MW unit. The results show that ambient air temperature is basically unchanged and the temperature of the boiler exhaust shows a linearly increasing trend with the increased air temperature of the air heater. With the temperature rise of the air heater

the heat exchange proportion of the air heater increases approximately linearly at medium and high loads

and at low load the ratio increases at first and then tends to be gentle. Based on the outage state of the low-low temperature economizer combined heater system

within the experimental range

the reduction of the heat rate of steam turbine is linear with the recuperated heat

the increase of the thermal efficiency of the boiler is positively correlated with the increase of air temperature of the air heater outlet

the decrease of coal consumption of power supply is positively correlated with the increase of air temperature of the air heater outlet and the proportion of the absorbed heat at the air heater side. In actual operation

when the air temperature of the air heater outlet is controlled at 70 ℃

the economy of the overall unit is best. The results of this study provide some technical references for improving the economy of thermal power units.

关键词

Keywords

references

Views

214

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Application of two-stage double-cycle flue gas waste heat utilization system

Experimental study on economical efficiency of high proportion lignite blended combustion in a large scale CFB boiler

Economic analysis for separated system of low pressure economizer and air heater

Parameter optimization for combined system of low pressure economizer and air heater

Research on peaking capacity and economy of bypass heat storage scheme for double reheat units

Related Author

WANG Lin

NIU Kun

GAO Jinghui

ZHANG Yafu

WANG Hongyu

MENG Yingqi

CAI Bin

ZHAO Zhiyong

Related Institution

Inner Mongolia Electric Power Research Institute

Northern United Power Co., Ltd

上海电力大学能源与机械工程学院

School of Mechanical and Electrical Engineering, Shandong University of Science and Technology

Air Force Dalian Communication Officer School

AI问答

⁰