Thermal hydrodynamic characteristics and wall temperature distribution of an ultra-supercritical 1 000 MW unit double-reheat tower type boiler

AN Jihua; MA Qinghua; ZHANG Yifan; BAI Wengang; LI Hongzhi

doi:10.19666/j.rlfd.201805118

English

您当前的位置：

首页 >

文章列表页 >

Thermal hydrodynamic characteristics and wall temperature distribution of an ultra-supercritical 1 000 MW unit double-reheat tower type boiler

Thermal Power Generation Vol. 47, Issue 12, Pages: 134-140(2018)

更新时间：2025-05-30

- Thermal hydrodynamic characteristics and wall temperature distribution of an ultra-supercritical 1 000 MW unit double-reheat tower type boiler
- 作者机构：
  
  1. 华能莱芜发电有限公司
  2. 西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201805118
  CLC： TK222;TK223.3+1
- Published Online：28 December 2018，
  
  Published：2018
- 稿件说明：
移动端阅览
AN Jihua, MA Qinghua, ZHANG Yifan, et al. Thermal hydrodynamic characteristics and wall temperature distribution of an ultra-supercritical 1 000 MW unit double-reheat tower type boiler[J]. Thermal Power Generation2018, 47(12): 134-140.
DOI：

AN Jihua, MA Qinghua, ZHANG Yifan, et al. Thermal hydrodynamic characteristics and wall temperature distribution of an ultra-supercritical 1 000 MW unit double-reheat tower type boiler[J]. Thermal Power Generation2018, 47(12): 134-140. DOI： 10.19666/j.rlfd.201805118.

摘要

超超临界二次再热锅炉运行参数高

其水冷壁服役环境更为苛刻

这对其水动力提出了更高的要求。本文以华能莱芜发电有限公司超超临界1 000 MW二次再热机组塔式锅炉为例

建立了水动力计算模型

通过现场数据采集和水动力计算相结合的方法

分析了BMCR、75%BMCR、50%BMCR、35%BMCR工况下的水动力特性及壁温分布规律。结果表明:下炉膛螺旋管圈水冷壁可以有效降低热负荷分布偏差带来的影响

明显减小流量分配偏差

抑制出口壁温偏差;上炉膛垂直管圈水冷壁虽然有一定的流量偏差

但由于超超临界二次再热机组塔式锅炉上炉膛内部有大量对流受热面

水冷壁的热负荷分布系数明显低于下炉膛

其壁温偏差仍然保持在合理的范围。

Abstract

The working parameters of ultra-supercritical double-reheat boilers are high

making the working environment of water wall more harsh

which puts forward higher requirements for hydrodynamic power of the boiler. In this paper

the ultra-supercritical 1 000 MW double-reheat tower type boiler in Huaneng Laiwu Power Generation Co.

Ltd. is taken as an example for the detailed thermal hydrodynamic research. Based on data from both field measurement and theoretical calculation

thermal hydrodynamic characteristics and wall temperature distributions are analyzed

under BMCR

75%BMCR

50%BMCR

35%BMCR condition. The results show that

the deviations of both mass flow rate and wall temperature decrease by using the spiral tube water wall in the lower furnace. Although there is somewhat deviation of mass flow rate in the vertical upward water wall

the wall temperature distribution is still in a reasonable region

due to a large scale of convective heat transfer area in the higher furnace.

关键词

Keywords

references

Views

288

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Flow distribution characteristics of water wall in a 600MW unit boiler in thermal state

Design scheme and application of APS system in an ultra-supercritical 1000MW unit with double-reheat cycle

Research on coupling calculation method of combustion and hydrodynamics for water walls in ultra-supercritical double-reheat boilers

Influences of flue gas recirculation on thermal hydrodynamic and water wall temperature distribution in an ultra-supercritical double-reheat boiler

Denitration performance of an ultra-supercritical unit boiler with double-reheat cycle under full load conditions

Related Author

ZHOU Yunlong

YANG Ning

NIU Haiming

WU Dongli

YANG Shuang

AN Fengshuan

ZHANG Wei

CHEN Wei

Related Institution

School of Energy and Power Engineering, Northeast Electric Power University

Beijing Guodian Zhishen Control Technology Co., Ltd

Guodian Taizhou Power Generation Co., Ltd

East China Electric Power Design Institute Co., Ltd

Institute of Thermal Engineering, Shanghai Jiao Tong University

AI问答

⁰