Feasibility analysis for chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using catalytic citric acid

LIU Feng; LIU Yongbing; YAO Hongmeng; SUN Yaping; YAO Jiantao; LONG Guojun; ZHAO Feng

doi:10.19666/j.rlfd.201812215

English

您当前的位置：

首页 >

文章列表页 >

Feasibility analysis for chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using catalytic citric acid

Thermal Power Generation Vol. 48, Issue 6, Pages: 79-83(2019)

更新时间：2025-09-28

- Feasibility analysis for chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using catalytic citric acid
- 作者机构：
  
  1. 西安热工研究院有限公司
  2. 华能山东石岛湾核电有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201812215
  CLC： TK284
- Published Online：10 June 2019，
  
  Published：2019
- 稿件说明：
移动端阅览
LIU Feng, LIU Yongbing, YAO Hongmeng, et al. Feasibility analysis for chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using catalytic citric acid[J]. Thermal Power Generation, 2019, 48(6): 79-83.
DOI：

LIU Feng, LIU Yongbing, YAO Hongmeng, et al. Feasibility analysis for chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using catalytic citric acid[J]. Thermal Power Generation, 2019, 48(6): 79-83. DOI： 10.19666/j.rlfd.201812215.

摘要

基于对高温气冷堆二回路化学清洗技术风险的分析

本文对高温气冷堆二回路柠檬酸清洗的可行性进行了研究。针对高温气冷堆二回路材质的多样性

进行了缓蚀剂体系的筛选;研究了Fe~(3+)存在对典型材质腐蚀影响

以及阀门密封面临近碳钢的电偶腐蚀情况。研究结果表明:复配型缓蚀剂可有效控制材料的腐蚀速率;低等级钢对Fe~(3+)较为敏感

实际清洗过程中应注意Fe~(3+)的控制;阀门密封面临近碳钢的腐蚀速率满足《化学清洗缓蚀剂应用性能评价指标及试验方法》(DL/T 523—2017)要求。

Abstract

On the basis of analyzing technical risk of chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using catalytic citric acid

the feasibility of the chemical cleaning of the secondary circuit in high temperature gas-cooled reactors using citric acid is researched. In view of various grades of steel used in the secondary circuit in high temperature gas-cooled reactors

the inhibitors system are selected.The influence of Fe~(3+) on corrosion of typical materials is discussed

and the galvanic corrosion of carbon steel near the valve sealing surface is analyzed. The results indicate that

the compound inhibitors can effectively control the corrosion rates of typical materials. The low grade steels are sensitive to Fe~(3+) in catalytic citric acid solution. The corrosion rate of carbon steel near the valve sealing surface could satisfy the requirement of Practice Evaluation and Testing Method of Inhibitors for Chemical Cleaning(DL/T 523—2017).

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Practicability of solving superheater oxides by chemical cleaning using recombination citric acid

PROBLEMS EXISTING IN OPERATION OF WET LIMESTONE/GYPSUM DESULFURATION SYSTEM IN LUOHUANG POWER PLANT AND ANALYSIS THEREOF

CAUSE ANALYSIS OF CORROSION FOR CHEMICAL-DOSING TUBE ENTERING INTO THE DRUM PORT

CAUSE ANALYSIS AND PROTECTIVE MEASURES FOR CORROSIVE PERFORATION OF CONDENSER’S COPPER TUBES IN YUNFU POWER PLANT

CHEMICAL CLEANING OF THERMODYNAMIC SYSTEM FOR 2×600 MW SUPERCRITICAL UNITS IN HUANENG QINBEI POWER PLANT

Related Author

LIN WeiLi

DENG Yuqiang

ZHANG Xiangjin

CAO Jieyu

LIU Feng

CHEN Shao min

ZHANG Cuihong

LI Lin

Related Institution

North School of Information Engineering, Xi'an University of Technology

Chongqing Electric Power College Chongqing

Shengli Power Plant Dongying

Yunfu Power Plant Guangdong Yunfu

Yunfu Power Plant

AI问答

⁰