Theory analysis and application of two kinds of technologies for ammonia production by urea hydrolysis

HUA Licun; WU Chunhua; MA Wenjie; ZHU Wenyu; ZHENG Wei

doi:10.19666/j.rlfd.201903056

English

您当前的位置：

首页 >

文章列表页 >

Theory analysis and application of two kinds of technologies for ammonia production by urea hydrolysis

Thermal Power Generation Vol. 48, Issue 11, Pages: 135-140(2019)

更新时间：2025-09-28

- Theory analysis and application of two kinds of technologies for ammonia production by urea hydrolysis
- 作者机构：
  
  1. 中国电力工程顾问集团西北电力设计院有限公司
  2. 上海电力大学环境与化学工程学院
  3. 成都锐思环保技术股份有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201903056
  CLC： X511;TM621
- Published Online：29 October 2019，
  
  Published：2019
- 稿件说明：
移动端阅览
HUA Licun, WU Chunhua, MA Wenjie, et al. Theory analysis and application of two kinds of technologies for ammonia production by urea hydrolysis[J]. Thermal Power Generation, 2019, 48(11): 135-140.
DOI：

HUA Licun, WU Chunhua, MA Wenjie, et al. Theory analysis and application of two kinds of technologies for ammonia production by urea hydrolysis[J]. Thermal Power Generation, 2019, 48(11): 135-140. DOI： 10.19666/j.rlfd.201903056.

摘要

本文介绍和比较了不添加催化剂和添加催化剂2种烟气脱硝用尿素水解制氨技术

对比2种制氨工艺的反应机理、反应速率、能耗、跟随机组负荷变化等情况发现:2种制氨工艺的设计温度为160℃

且该温度下2种制氨工艺的反应速率相同;但加入催化剂—磷酸二氢铵和磷酸氢二铵后

易导致尿素水解反应体系的pH值降低

对反应设备的腐蚀风险性增加;2种制氨工艺的能耗相同

且均能及时响应随机组负荷变化。目前

在电厂制氨工艺中

主要以不添加催化剂的尿素水解工艺为主。

Abstract

Two types of ammonia production technologies by urea hydrolysis for flue gas denitrification were introduced and compared

which include adding catalyst and without adding catalyst. The reaction mechanism

reaction rate

energy consumption and capacity of following the unit load change of the above two ammonia production technologies were theoretically analyzed and practically compared. The results show that

at the designed reaction temperature 160 ℃ for both the two technologies

the reaction rate of them were the same. However

after the catalysts

the ammonium dihydrogen phosphate and diammonium hydrogen phosphate

were added

the p H value of the urea hydrolysis reaction system decreased

which increased the corrosion risk of the hydrolytic equipment. The two technologies had the same energy consumption

and both can meet the demand of load respond. At present

power plants mainly apply the technology of ammonia production without catalyst addition.

关键词

Keywords

references

Views

436

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Energy saving reformation for catalytic hydrolysis of boiler flue gas denitration urea pyrolysis furnace

Deposit formation in denitration urea pyrolysis system:cause analysis and countermeasures

Surface properties and flue gas denitrification performance of honeycomb CuO/γ-Al₂O₃ catalysts

Influence of inlet velocity field and component concentration distribution on de-NO_x efficiency of SCR denitration systems

Variation characteristics of coal ash in an ultra supercritical 1000MW unit equipped with SCR denitration device

Related Author

WU Yan

YANG Tianming

LIU Chengwu

LIU Zhengxiu

WANG Libiao

ZHANG Yunqing Beijing Jingneng Thermal Power Co.

WANG Xuetao

JIAO Yefan

Related Institution

State Power Investment Corporation Inner Mongolia Energy Co., Ltd

Beijing Jingneng Thermal Power Co., Ltd

School of Vehicle and Power Engineering, Henan University of Science and Technology

Datang Ma'anshan Dangtu Power Generation Co., Ltd

Huadian Electric Power Research Institute

AI问答

⁰