Equipment optimization for burning Shenhua coal in a 330MW coal-fired unit

GAO Yongkun; LI Xingzhi; DING Hongsheng; MENG Yi; LUO Huan; ZHANG Yingmin

doi:10.19666/j.rlfd.202007067

English

您当前的位置：

首页 >

文章列表页 >

Equipment optimization for burning Shenhua coal in a 330MW coal-fired unit

Thermal Power Generation Vol. 50, Issue 3, Pages: 176-181(2021)

更新时间：2025-09-28

- Equipment optimization for burning Shenhua coal in a 330MW coal-fired unit
- 作者机构：
  
  1. 天津国电津能热电有限公司
  2. 西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202007067
  CLC： TK16
- Published Online：22 February 2021，
  
  Published：2021
- 稿件说明：
移动端阅览
GAO Yongkun, LI Xingzhi, DING Hongsheng, et al. Equipment optimization for burning Shenhua coal in a 330MW coal-fired unit[J]. Thermal Power Generation, 2021, 50(3): 176-181.
DOI：

GAO Yongkun, LI Xingzhi, DING Hongsheng, et al. Equipment optimization for burning Shenhua coal in a 330MW coal-fired unit[J]. Thermal Power Generation, 2021, 50(3): 176-181. DOI： 10.19666/j.rlfd.202007067.

摘要

天津国电津能热电有限公司2×330 MW机组锅炉在掺烧神华煤过程中出现了严重结渣现象

为此电厂对燃用神华煤的2号锅炉燃烧系统进行了重新设计和调整

并在易结渣区域增加了26支吹灰器。优化改造后

锅炉结渣明显改善

空气预热器入口烟气温度降低11℃;飞灰含碳量和CO生成量基本不变

SCR装置入口NO_x生成质量浓度降低30 mg/m~3

锅炉效率升高0.3%

停炉检查发现炉膛区域和屏区结渣明显减轻。

Abstract

Serious slagging occurred in 2×330MW unit boilers of Tianjin Guodian Jinneng Thermal Power Plant when burning Shenhua coal. To solve this problem

the power plant redesigned and adjusted the combustion system of No.2 boiler

and added 26 steam soot-blowers in the slagging area. After the optimization

the slagging situation was dramatically eased

the flue gas temperature at inlet of the air preheater decreased by 11℃

the carbon content in fly ash and quantity of CO produced had little change basically

the mass concentration of NO_x at the SCR denitration system inlet decreased by 30 mg/m~3

and the boiler efficiency increased by 0.3%. It was found that the slagging in the furnace area and the platen area was significantly reduced after boiler shutdown.

关键词

Keywords

references

Views

118

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

SLAGGING PREVENTION TECHNOLOGY FOR BURNING SHENHUA COAL IN TANGENTIAL FIRING BOILERS

CAUSES LEADING TO SLAGGING IN FURNACE OF TANGENTIAL FIRING PULVERIZED COAL BOILER AND PREVENTIVE MEASURES THEREOF

STUDY ON SCHEME OF PREVENTING A 200T/H COALFIRING BOILER FROM SLAGGING PROBLEMS

CAUSE ANALYSIS OF SLAGGING IN BOILERS BURNING SHENFU DONGSHENG COAL AND PREVENTIVE MEASURES THEREOF

TEST STUDY ON POLLUTION BEHAVIOR OF HEATING SURFACE IN BOILERS BURNING SHENHUA COAL

Related Author

WANG Pingang1

SONG Chang2

WANG Yueming31.Shenhua Group Corporation

HU Min

RAO Supo

HU Dianru

ZHANG Bo

WEN Jun

Related Institution

Shenhua Group Co., Ltd

Shenhua Guohua Electric Power Branch

Shajiao C Power Plant

Guangdong Yuedian Group Co., Ltd.

AI问答

⁰