Synergistic removal of condensable particulate matter by flue gas cleaning devices of coal-fired power plant

ZHANG Fajie; HE Chuan; XIE Jiannan; LIU Xiaomin; XU Jizhuang; HUANG Jianxun; HUANG Rongting; YANG Linjun; WANG Lele; KONG Fanhai

doi:10.19666/j.rlfd.202012184

English

您当前的位置：

首页 >

文章列表页 >

Synergistic removal of condensable particulate matter by flue gas cleaning devices of coal-fired power plant

Thermal Power Generation Vol. 50, Issue 7, Pages: 143-149(2021)

更新时间：2025-09-28

- Synergistic removal of condensable particulate matter by flue gas cleaning devices of coal-fired power plant
- 作者机构：
  
  1. 苏州西热节能环保技术有限公司
  2. 厦门华夏国际电力发展有限公司
  3. 东南大学能源热转换及其过程测控教育部重点实验室
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202012184
  CLC： X773
- Published：2021
- 稿件说明：
移动端阅览
ZHANG Fajie, HE Chuan, XIE Jiannan, et al. Synergistic removal of condensable particulate matter by flue gas cleaning devices of coal-fired power plant[J]. Thermal Power Generation, 2021, 50(7): 143-149.
DOI：

ZHANG Fajie, HE Chuan, XIE Jiannan, et al. Synergistic removal of condensable particulate matter by flue gas cleaning devices of coal-fired power plant[J]. Thermal Power Generation, 2021, 50(7): 143-149. DOI： 10.19666/j.rlfd.202012184.

摘要

可凝结颗粒物(CPM)在燃煤机组烟气排放的总颗粒物中有较大占比。为分析燃煤电站环保设备对CPM的脱除效果

对某超低排放燃煤机组现有低低温电除尘、海水脱硫和湿式电除尘环保设备进、出口的CPM进行了测试。结果表明:在机组300 MW高负荷和150 MW低负荷条件下

上述3个环保设备能够有效脱除CPM

总CPM整体脱除率分别为97.2%和97.6%

对应排放质量浓度分别为5.58 mg/m~3和5.55 mg/m~3;干式电除尘和湿式电除尘对无机CPM的脱除效率大于对有机CPM的脱除效率;海水脱硫整体对CPM脱除作用显著

但会将海水中大量存在的Cl-离子和Na+离子带入烟气中形成一部分新的CPM

下游的湿式电除尘则能够将这些新生成的CPM脱除

最终保证了CPM的低浓度排放。

Abstract

Condensable particulate matter(CPM) contributes a considerable proportion to the total particulate matter emitted by coal-fired power plants. In order to analyze the removal effect of CPM by existing flue gas cleaning devices

the CPM from the inlet and outlet of low-low temperature electrostatic precipitator(LLTESP)

the seawater flue gas desulfurization(SWFGD) and the wet electrostatic precipitator(WESP) of a coal-fired power plant which had implemented the ultra-low emission reform

were tested and studied. The results show that

at both 300 MW(high load) and 150 MW(low load)

the three devices mentioned above can remove the CPM effectively

and the total removal efficiency reached 97.2% and 97.6% respectively

with CPM emission concentration of 5.58 mg/m~3 and 5.55 mg/m~3 respectively. The inorganic CPM were removed more effectively than the organic CPM by both ESP and WESP. The overall removal of CPM by SWFGD was obvious

however

the Cl-anion and the Na+ cation from the sea water would be brought into the flue gas

forming a new part of CPM. The new formed CPM were removed by the WESP subsequently

ensuring a low emission concentration of CPM.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Ultra-low emission reform and its influence on the plant's electricity supply cost

Experimental study on fine particle emission characteristics of ultra-low emission coal-fired units

Migration characteristics of SO₃ and condensable particulate matters in ultra-low emission coal-fired power plants

INFLUENCE OF SCR DENITRIFICATION FACILITY UPON THE BOILER STRUCTURE

DESIGN OF AMMONIA EVAPORATOR FOR SCR DENITRIFICATION SYSTEM OF ULTRA-SUPERCRITICAL 2×1036MW UNITS

Related Author

CUI Liming

MENG Lixia

YUAN Hong

CHEN Hongwei

LIANG Zhanwei

ZHAO Bin

GAO Mingfei

ZHANG Meiyou

Related Institution

Shenhua Group Co., Ltd

China Energy Conservation and Emission Reduction Co., Ltd

Shenhua Guohua Electric Power Research Center

College of Energy, Power and Mechanical Engineering, North China Electric Power University

College of Metallurgy and Energy, North China University of Science and Technology

AI问答

⁰