Thermomechanical performance analysis for waste heat recovery and utilization system of cement kiln coupled with coal-fired power plant

WANG Yihan; LI Jiarui; CHEN Heng; XU Gang; LEI Jing; LIU Tong

doi:10.19666/j.rlfd.202108158

English

您当前的位置：

首页 >

文章列表页 >

Thermomechanical performance analysis for waste heat recovery and utilization system of cement kiln coupled with coal-fired power plant

Thermal Power Generation Vol. 51, Issue 6, Pages: 111-121(2022)

更新时间：2025-09-28

- Thermomechanical performance analysis for waste heat recovery and utilization system of cement kiln coupled with coal-fired power plant
- 作者机构：
  
  华北电力大学能源动力与机械工程学院
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202108158
  CLC： TM621
- Published：2022
- 稿件说明：
移动端阅览
WANG Yihan, LI Jiarui, CHEN Heng, et al. Thermomechanical performance analysis for waste heat recovery and utilization system of cement kiln coupled with coal-fired power plant[J]. Thermal Power Generation, 2022, 51(6): 111-121.
DOI：

WANG Yihan, LI Jiarui, CHEN Heng, et al. Thermomechanical performance analysis for waste heat recovery and utilization system of cement kiln coupled with coal-fired power plant[J]. Thermal Power Generation, 2022, 51(6): 111-121. DOI： 10.19666/j.rlfd.202108158.

摘要

提出了一种更高效的耦合燃煤机组的水泥窑余热回收利用系统，采用水泥窑炉排冷却器排出空气和旋风预热器废气的热量加热燃煤机组的部分凝结水，从而节省汽轮机抽汽，增加汽轮机做功，同时根据热力学第一和第二定律分析余热利用系统性能提升的原因。结果表明：耦合燃煤机组后水泥窑余热利用系统效率显著提升，机组发电量得到提高；与常规水泥窑余热利用系统相比，所提出余热利用系统可增加6.83 MW净发电功率；此外，余热利用系统的发电效率和净热效率提高了18.25百分点和8.17百分点；系统发电(火用)效率和总(火用)效率分别提升了39.37百分点和29.24百分点。经济分析表明，所提出余热利用系统省去了部分设备，投资成本低，回收周期短，净现值高，经济优势明显。

Abstract

An advanced cement kiln waste heat recovery system(WHRS) coupled with coal-fired power plant is proposed. The heat of the exhaust from clinker cooler and the waste gas of cyclone preheater is used to heat part of the feedwater of coal-fired power plant

thereby saving steam extraction from the turbine and increasing the steam turbine work. According to the first and second laws of thermodynamics

the reasons for the waste heat utilization system performance improvement are analyzed. The results show that

the coupled system increases the power generation and significantly improves the efficiency of the waste heat recovery system. Compared with the conventional cement plants waste heat recovery system

the proposed waste heat recovery system can increase the net power generation by 6.83 MW. Moreover

the power generation efficiency and net thermal efficiency of the system increases by 18.25 percentage points and 8.17 percentage points

and the power generation exergy efficiency and total exergy efficiency of the system increases by 39.37 percentage points and 29.24 percentage points

respectively. Economic analysis shows that the proposed waste heat recovery system saves part of the equipment

has low investment cost

short recovery period

high net present value and obvious economic advantages.

关键词

Keywords

references

Views

203

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Experimental study on heat recovery via flash of desulphurization slurry

Heat-mass transfer and chemical reaction characteristics during carbon dioxide absorption by amine solution in spray scrubber

Thermal parameter optimization for dual pressure waste heat recovery generation system of a new dry process cement kiln

Experimental study on cohesive characteristics of cement raw meal ash on SP boiler tubes

Comprehensive evaluation for large scale coal-fired power units based on combined weight and TOPSIS method

Related Author

XU Shiming

XU Haitao

AN Hang

QI Zheng

ZHOU Xian

PENG Shuo

ZHU Hongqing

GUO Feng

Related Institution

Huaneng Yingkou Thermal Power Co., Ltd

Hulunbuir Antai Thermal Power Co., Ltd. Hailar Thermal Power Plant

China Huaneng Group Clean Energy Technology Research Institute Co., Ltd

National Nuclear Power Planning and Design Institute Co., Ltd

CITIC Heavy Industry Machinery Co., Ltd

AI问答

⁰