Cause analysis and countermeasures for gas wall blockage of a 5 MW class supercritical carbon dioxide boiler

WANG Lin; BAI Wengang; LI Hongzhi; LIU Gang; SONG Xiaohui; GAO Jinghui; WANG Hongyu; MENG Yingqi

doi:10.19666/j.rlfd.202111238

English

您当前的位置：

首页 >

文章列表页 >

Cause analysis and countermeasures for gas wall blockage of a 5 MW class supercritical carbon dioxide boiler

Thermal Power Generation Vol. 51, Issue 5, Pages: 142-148(2022)

更新时间：2025-09-28

- Cause analysis and countermeasures for gas wall blockage of a 5 MW class supercritical carbon dioxide boiler
- 作者机构：
  
  西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202111238
  CLC： TM621.2
- Published：2022
- 稿件说明：
移动端阅览
WANG Lin, BAI Wengang, LI Hongzhi, et al. Cause analysis and countermeasures for gas wall blockage of a 5 MW class supercritical carbon dioxide boiler[J]. Thermal Power Generation, 2022, 51(5): 142-148.
DOI：

WANG Lin, BAI Wengang, LI Hongzhi, et al. Cause analysis and countermeasures for gas wall blockage of a 5 MW class supercritical carbon dioxide boiler[J]. Thermal Power Generation, 2022, 51(5): 142-148. DOI： 10.19666/j.rlfd.202111238.

摘要

针对西安热工研究院有限公司（西安热工院）5 MW级超临界二氧化碳（S-CO_2）锅炉启动过程中气冷壁堵塞问题，结合现场情况开展了原因分析。发现机组充气过程中工质多次发生节流膨胀，制冷降温效果显著，气冷壁底部集箱内存水结冰；CO_2温度降低而压力逐步提高，发生液化并封闭了集箱；锅炉点火后，液化的CO_2与结冰的水分封闭了通流孔，阻断了工质流动，致使气冷壁无法得到有效冷却，锅炉金属壁温蹿升剧烈。对此，现场实施了小火暖炉、降压闪蒸、末端排水及优化工质充装参数等改进措施，取得了良好效果。经调试调整后，锅炉点火启动正常，金属壁温升速合理，相关经验可供后续同类机组参考。

Abstract

Aiming at solving the gas wall blockage problem occurred in the 5 MW class supercritical carbon dioxide(S-CO_2) boiler of Xi'an Thermal Power Research Institute Co.

Ltd.(TPRI) during start up process

cause analysis was carried out combining with the field situation. It was found that

during gas charging process of the unit

the working medium throttled and expanded for many times

the cooling effect was remarkable

and the water in the header at the bottom of the gas wall froze. The CO_2 temperature decreased and the pressure gradually increased

resulting in liquefaction and sealing of the header. After ignition of the boiler

the liquefied CO_2 and frozen water closed the through-hole and blocked the flow of the working medium

thus the gas wall could not be effectively cooled

and the metal wall temperature of the boiler rose sharply. Based on the above analysis

improvement measures such as small fire heater

depressurization flash

end drainage and optimization of working medium filling parameters were implemented

and good effects were achieved. After debugging and adjustment

the ignition and start-up of the S-CO_2 boiler turned normal

and the metal wall temperature rise rate was reasonable. The relevant experience can provide reference for similar units in the future.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Research progress of conversion and utilization of upgraded lignite by hydrothermal dewatering

Study on peak regulation capacity of a coal-fired supercritical carbon dioxide cogeneration unit

Study and application of performance simulation of supercritical CO₂ closed cycles

Study on PCHE in advances sodium cold fast reactor coupled supercritical carbon dioxide Brayton cycle: a review

Research on performance prediction model of supercritical carbon dioxide centrifugal compressor

Related Author

LIU Jianzhong

WU Junhong

WANG Zhihua

CEN Kefa

WU Zuolian

ZHANG Yifan

ZHANG Chun

LI Hongzhi

Related Institution

State Key Laboratory of Clean Energy Utilization

State Key Laboratory of Clean Energy Utilization, Zhejiang University

School of Hydraulic and Civil Engineering, Shandong Agricultural University

AVIC Hunan Power Machinery Research Institute

China Academy of Atomic Energy Sciences

AI问答

⁰