Numerical simulation of NO<sub>x</sub> reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler

BAI Hao; ZHANG Zhongxiao; LI Zixiang; GUO Xinwei; ZHANG Jian; WU Xiaojiang

doi:10.19666/j.rlfd.202212174

English

您当前的位置：

首页 >

文章列表页 >

Numerical simulation of NO_x reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler

Thermal Power Generation Vol. 52, Issue 5, Pages: 136-144(2023)

更新时间：2025-09-28

- Numerical simulation of NO_x reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler
- 作者机构：
  
  1. 上海理工大学环境与建筑学院
  2. 上海交通大学机械与动力工程学院
  3. 华北水利水电大学乌拉尔学院
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202212174
  CLC： X701
- Published：2023
- 稿件说明：
移动端阅览
BAI Hao, ZHANG Zhongxiao, LI Zixiang, et al. Numerical simulation of NO_x reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler[J]. Thermal Power Generation, 2023, 52(5): 136-144.
DOI：

BAI Hao, ZHANG Zhongxiao, LI Zixiang, et al. Numerical simulation of NO_x reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler[J]. Thermal Power Generation, 2023, 52(5): 136-144. DOI： 10.19666/j.rlfd.202212174.

摘要

以330 MW机组煤粉锅炉为研究对象，采用数值模拟方法研究了水煤浆热解气的脱硝作用，重点讨论了主燃区过量空气系数α_1和热解气比例β对炉内燃烧特性和NO_x排放的影响规律。结果表明：当β保持不变时，随着α_1减小，主燃区温度降低，燃尽区及炉膛出口温度升高；同时，α_1的减小增强了主燃区的还原性气氛，有利于提高热解气的脱硝速率，从而降低炉膛出口的NO_x质量浓度，但α_1的减小会影响煤粉的燃烧性能并使得炉膛出口CO增多；随着β的增加，炉膛火焰中心上移，热解气对NO_x的还原速率升高；当β从5%增至20%时，炉膛整体的NO_x质量浓度呈现先减小后增大的趋势，β=15%时NO_x质量浓度最低，热解气的NO_x还原效率为44.35%。

Abstract

The denitrification effect of coal-water slurry pyrolysis gas is investigated by numerical simulation in a 330 MW power station pulverized coal boiler

focusing on the influence law of excess air coefficient α_1 in the primary combustion zone(PCZ) and pyrolysis gas ratio β on the combustion characteristics and NO_x emission in the furnace. The results show that

when β is kept constant

the temperature of the PCZ decreases and the temperature of over-fire air(OFA) zone and furnace outlet increases as α_1 decreases. Meanwhile

the decrease of α_1 enhances the reducing atmosphere in the PCZ

which is beneficial to improve the denitrification rate of pyrolysis gas and thus to reduce the NO_x mass concentration at the furnace outlet. But the decrease of α_1 will affect the combustion performance of the pulverized coal and increase the CO concentration at the furnace outlet. With the increase of β

the center of the furnace flame moves up and the reduction rate of NO_x by pyrolysis gas increases. When β increases from 5% to 20%

the overall mass concentration of NO_x in the furnace shows a trend of first decreasing and then increasing

and when β=15%

the NO_x mass concentration reaches the lowest and the NO_x reduction efficiency of the pyrolysis gas reaches 44.35%.

关键词

Keywords

references

Views

134

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

Effect of blending CO₂ into air on combustion characteristics of CH₄

Effect of overfire air on combustion and NO_x formation characteristics in a 1 000 MW ultra-supercritical boiler

Numerical simulation on effect of F secondary air declination on combustion of a down-fired boiler

Numerical study on combustion characteristics of a tangentially fired pulverized-coal boiler in O₂/CO₂ atmosphere

Numerical simulation on mixed combustion characteristics of coal-bed methane and pulverized coal in a 600 MW unit boiler

Related Author

ZHANG Gaoqiang

ZHANG Tianqing

FU Zhongguang

SONG Jiasheng

GAO Yucai

ZHOU Ke

LIU Mingyu

CHEN Shengjun

Related Institution

Key Laboratory of Power Station Equipment Status Detection and Control, Ministry of Education, North China Electric Power University

Key Laboratory of Low Grade Energy Utilization Technology and Systems, Ministry of Education, Chongqing University

Xi'an Thermal Power Research Institute Co., Ltd

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

Huaneng (Zhejiang) Energy Development Co., Ltd. Yuhuan Branch

AI问答

⁰

Numerical simulation of NOx reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler

DOI：10.19666/j.rlfd.202212174

摘要

Abstract

关键词

Keywords

references

Numerical simulation of NO_x reduction by injecting coal-water slurry pyrolysis gas into reduction zone of a 330 MW pulverized coal boiler