高湿污泥阴燃处置中生物质调质强化阴燃传播行为实验研究

陈禹博; 马仑; 李开源; 乔瑜; 叶骥

doi:10.19666/j.rlfd.202504078

English

您当前的位置：

首页 >

文章列表页 >

高湿污泥阴燃处置中生物质调质强化阴燃传播行为实验研究

Thermal Power Generation Vol. 55, Issue 3, Pages: 72-81(2026)

更新时间：2026-08-07

- 高湿污泥阴燃处置中生物质调质强化阴燃传播行为实验研究
- 作者机构：
  
  1. 武汉理工大学安全科学与应急管理学院
  2. 华中科技大学煤燃烧与低碳利用全国重点实验室
  3. 广东能源集团科学技术研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202504078
  CLC： X703
- Published：2026
- 稿件说明：
移动端阅览
[1]陈禹博,马仑,李开源,等.高湿污泥阴燃处置中生物质调质强化阴燃传播行为实验研究[J].热力发电,2026,55(03):72-81.
[1]陈禹博,马仑,李开源,等.高湿污泥阴燃处置中生物质调质强化阴燃传播行为实验研究[J].热力发电,2026,55(03):72-81. DOI： 10.19666/j.rlfd.202504078.

DOI：10.19666/j.rlfd.202504078.

摘要

阴燃处置技术作为新兴的高湿固体废物处理手段，在处置高湿低热值污泥方面展现出独特优势，然而其自持传播过程易受物料特性与运行参数影响，存在反应强度衰减导致的传播失稳风险。故以含水率大于65%的高湿污泥为处置对象，系统考察石英砂与污泥掺混质量比（2:1～5:1）、空气达西流速（5～8 cm/s）对生物质调质原料污泥的阴燃传播特性影响，探究阴燃完全传播的生物质调质比例边界。结果表明：在固定达西流速为5 cm/s条件下，石英砂与污泥掺混比从2:1增加到5:1时，维持阴燃完全传播的临界生物质调质比例从4%呈线性增长至10%，阴燃系统临界单位热值稳定于0.339 MJ/kg；当石英砂与污泥掺混比例固定为3:1时，达西流速由5 cm/s提升至8 cm/s，临界生物质调质比例从6%也基本呈现线性递减至2%，对应临界单位热值由0.339 MJ/kg线性降至0.172 MJ/kg；阴燃处置后物料存在塌陷特征，且当生物质调质比例超过临界值后，其含量变化对顶部塌陷高度无显著影响。该研究结果可为解决高湿污泥高效阴燃处置提供参考。

Abstract

As an emerging high-moisture solid waste treatment method

smoldering disposal technology shows unique advantages in the disposal of high-moisture and low-calorific sludge. However

its self-sustaining propagation process is easily affected by material characteristics and operating parameters

and there is a risk of propagation instability caused by the attenuation of reaction intensity. Taking high-moisture sludge(moisture content 65%) as the disposal object

this study systematically investigates the effects of the mixing ratio of quartz sand to sludge(2:1～5:1) and air Darcy velocities(5～8 cm/s) on smoldering propagation under biomass conditioning

and explores the boundary of biomass conditioning ratio for complete smoldering propagation. The results show that under the condition of a fixed Darcy flow rate of 5 cm/s

the critical biomass conditioning ratio linearly increases from 4% to 10% and the critical unit calorific value of the smoldering system remains stable at approximately 0.339 MJ/kg when the sand-sludge mixing ratio is increased from 2:1 to 5:1. When the sand-sludge mixing ratio is fixed at 3:1

the critical biomass conditioning ratio linearly decreases from 6% to 2% when the air Darcy velocity increases from 5 cm/s to 8 cm/s

corresponding to a linear decrease in critical unit calorific value from 0.339 MJ/kg to 0.172 MJ/kg. The material exhibits collapse characteristics after smoldering disposal

and the biomass conditioning ratio has no significant effect on the top collapse height when it exceeds the critical value. These results can provide reliable scientific references for solving the efficient smoldering disposal of high-moisture sludge.

关键词

Keywords

references

HUANG Q, YU B, QIU K, et al. Effect of moisture on sewage sludge combustion temperature profile and heavy metal leaching[J]. Drying Technology, 2016, 34:1810-1819.

PATHAK A, DASTIDAR M G, SREEKRISHNAN T R.Bioleaching of heavy metals from sewage sludge:a review[J]. Journal of Environmental Management, 2009,90:2343-2353.

CHEN H, YAN S H, YE Z L, et al. Utilization of urban sewage sludge:Chinese perspectives[J]. Environmental Science and Pollution Research, 2012, 19:1454-1463.

FENG C, HUANG J, YANG C, et al. Smouldering combustion of sewage sludge:Volumetric scale-up,product characterization, and economic analysis[J]. Fuel,2021, 305:121485.

XIANG Q, FAN D, ZHU L, et al. Weighted comprehensive risk assessment and pollution analysis of long-term printing and dyeing sludge landfills in an industrialized Chinese city[J]. Environmental Pollution,2025, 367:125665.

AL HAZMI H E, HASSAN G K, KURNIAWAN T A, et al.Technological solutions to landfill management:towards recovery of biomethane and carbon neutrality[J]. Journal of Environmental Management, 2024, 354:120414.

LI H, LI M, WANG H, et al. A review on migration and transformation of nitrogen during sewage sludge thermochemical treatment:focusing on pyrolysis,gasification and combustion[J]. Fuel Processing Technology, 2023, 240:107562.

TAN P, MA L, XIA J, et al. Co-firing sludge in a pulverized coal-fired utility boiler:combustion characteristics and economic impacts[J]. Energy, 2017,119:392-399.

CAO J, JIANG Y, TAN X, et al. Sludge-based biochar preparation:pyrolysis and co-pyrolysis methods,improvements, and environmental applications[J]. Fuel,2024, 373:132265.

LI D, SHAN R, JIANG L, et al. A review on the migration and transformation of heavy metals in the process of sludge pyrolysis[J]. Resources, Conservation and Recycling, 2022, 185:106452.

AYOL A, YURDAKOS O T, GURGEN A. Investigation of municipal sludge gasification potential:gasification characteristics of dried sludge in a pilot-scale downdraft fixed bed gasifier[J]. International Journal of Hydrogen Energy, 2019, 44(32):17397-17410.

KHIARI B, MARIAS F, ZAGROUBA F, et al. Analytical study of the pyrolysis process in a wastewater treatment pilot station[J]. Desalination, 2004, 167:39-47.

PIRONI P, SWITZER C, REIN G, et al. Small-scale forward smouldering experiments for remediation of coal tar in inert media[J]. Proceedings of the Combustion Institute, 2009, 32:1957-1964.

YERMÁN L, WALL H, TORERO J L. Experimental investigation on the destruction rates of organic waste with high moisture content by means of self-sustained smoldering combustion[J]. Proceedings of the Combustion Institute, 2017, 36:4419-4426.

WYN H K, KONAROVA M, BELTRAMINI J , et al. Selfsustaining smouldering combustion of waste:a review on applications, key parameters and potential resource recovery[J]. Fuel Processing Technology, 2020, 205:106425.

RASHWAN T L, FOURNIE T, TORERO J L, et al.Scaling up self-sustained smouldering of sewage sludge for waste-to-energy[J]. Waste Management, 2021, 135:298-308.

KINSMAN L, TORERO J L, GERHARD J I. Organic liquid mobility induced by smoldering remediation[J].Journal of Hazardous Materials, 2017, 325:101-112.

ZHAO C, LI Y, GAN Z, et al. Method of smoldering combustion for refinery oil sludge treatment[J]. Journal of Hazardous Materials, 2021, 409:124995.

SERRANO A, WYN H, DUPONT L, et al. Selfsustaining treatment as a novel alternative for the stabilization of anaerobic digestate[J]. Journal of Environmental Management, 2020, 264:110544.

FABRIS I, CORMIER D, GERHARD J I, et al.Continuous self-sustaining smouldering destruction of simulated faeces[J]. Fuel, 2017, 190:58-66.

RASHWAN T L, GERHARD J I, GRANT G P.Application of self-sustaining smouldering combustion for the destruction of wastewater biosolids[J]. Waste Management, 2016, 50:201-212.

SERRANO A, WYN H, DUPONT L, et al. Selfsustaining treatment as a novel alternative for the stabilization of anaerobic digestate[J]. Journal of Environmental Management, 2020, 264:110544.

严超,张煜,黄经春,等.淀粉类厨余阴燃处置参数寻优及烟气释放特性[J].洁净煤技术, 2023, 29(9):87-97.YAN Chao, ZHANG Yu, HUANG Jingchun, et al.Optimization of starch kitchen waste smoldering disposal parameters and analysis of flue gas release characteristics[J]. Clean Coal Technology, 2023, 29(9):87-97.

成明锴,李琛,付建红,等.污泥阴燃过程及残渣特性分析研究[J].洁净煤技术, 2020, 26(5):166-172.CHENG Mingkai, LI Chen, FU Jianhong, et al. Study on the smouldering treatment of sewage sludge and its residue property[J]. Clean Coal Technology, 2020, 26(5):166-172.

GAN Z, ZHAO C, LI Y, et al. Experimental investigation on smoldering combustion for oil sludge treatment:influence of key parameters and product analysis[J]. Fuel,2022, 316:123354.

MA L, QIAO Y, HUANG J, et al. Self-sustained smouldering treatment technology for high-moisture sludge:pilot-scaled tests with continuous operation[J].Waste Management, 2024, 188:86-94.

TORERO J L, GERHARD J I, MARTINS M F, et al.Processes defining smouldering combustion:Integrated review and synthesis[J]. Progress in Energy and Combustion Science, 2020, 81:100869.

MA L, QIAO Y, ZHANG C, et al. Volumetric scaling up self-sustained smouldering of printing and dyeing sludge with high moisture content[J]. Journal of Cleaner Production, 2024, 450:141971.

YERMÁN L, HADDEN R M, CARRASCAL J, et al.Smouldering combustion as a treatment technology for faeces:exploring the parameter space[J]. Fuel, 2015, 147:108-116.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Publicity Resources

基于改进粒子群算法的水电机组振荡抑制控制器参数优化

可实现的新型卡诺电池与塔式光热并联系统及其协同优化研究

NiCe_xFe

基于电网约束与关键设备运行特性的风光氢储系统优化配置与经济性研究

基于物理信息神经网络的超临界燃煤发电机炉协调系统动态建模研究

Related Author

No data

Related Institution

No data

AI问答

⁰