掺烧氢/氨对煤粉锅炉NO

张波; 张国军; 贾子秀; 王志超; 李宗泰; 晋中华; 房凡

doi:10.19666/j.rlfd.202505075

English

您当前的位置：

首页 >

文章列表页 >

掺烧氢/氨对煤粉锅炉NO

热力发电 2025年54卷第8期页码：124-130

碳中性燃料耦合燃烧与排放控制 | 更新时间：2026-08-11

- 掺烧氢/氨对煤粉锅炉NO
- Effect of co-firing hydrogen/ammonia on nitrogen oxides emissions from boilers
- 作者机构：
  
  1. 西安热工研究院有限公司
  2. 北京中润汉泰科技有限公司
- 作者简介：
- 基金信息：
  
  国家重点研发计划项目(2023YFB4005704)~~
- DOI：10.19666/j.rlfd.202505075
  中图分类号： X773;TK229.63
- 纸质出版：2025
- 稿件说明：
移动端阅览
[1]张波,张国军,贾子秀,等.掺烧氢/氨对煤粉锅炉NO_x排放的影响[J],2025,54(08):124-130.
[1]张波,张国军,贾子秀,等.掺烧氢/氨对煤粉锅炉NO_x排放的影响[J],2025,54(08):124-130. DOI： 10.19666/j.rlfd.202505075.

DOI：10.19666/j.rlfd.202505075.

摘要

分析某600 MW燃煤机组掺烧氢/氨对NOx排放的影响。根据煤质分析及试验结果修正反应动力学文件，根据流体动力学(CFD)模拟结果构建完全搅拌全混流反应器(perfectly stirred reactor

psr)反应器网络，结合采用化学反应动力学分析方法，对锅炉在一次风、周界风、二次风、二次风后4个位置的5个方案，分别掺烧氢/氨后的NOx排放进行分析，结果表明：对于所研究的锅炉，氢气掺烧位置位于二次风方案，掺氢20%工况，NO降低32.4%、未燃尽碳排放量与纯煤工况相当；氨气掺烧位置位于二次风后方案，NO排放量略高于纯煤工况，未燃尽碳排放量显著减小。上述2个方案是该锅炉以NOx排放作为评价指标的掺氢/氨燃烧的推荐方案。该方法和结论可为掺烧氢/氨技术的工程实施提供设计依据。

Abstract

The effect of co-firing hydrogen/ammonia on nitrogen oxides emissions from boilers is investigated. The reaction kinetics file is modified based on coal quality analysis and experimental results. A psr reactor network based on CFD simulation results is constructed according to the fluid dynamics(CFD) simulation results. Combing with the chemical reaction kinetics analysis method

the NOx emissions after burning hydrogen/ammonia at four positions of primary air

peripheral air

secondary air and post secondary air in five schemes are analyzed. The results show that

for the researched boiler

when the hydrogen co-firing position is located in the secondary air scheme

and the hydrogen mixing ratio is 20%

the NO emission reduces by 32.4%

and the emission concentration of unburned carbon does not change much compared to the pure coal condition. When the ammonia co-firing position is located behind the secondary air

the NO emission mass concentration is slightly higher than that under the pure coal condition

and the emission mass concentration of unburned carbon reduces significantly. The above two schemes are recommended for co-firing hydrogen/ammonia in the coal-fired boiler

with nitrogen oxide emissions as the evaluation index. This method and conclusion provides a theoretical basis for the engineering implementation of hydrogen/ammonia co-firing technology.

关键词

Keywords

references

WANG X, FAN W D, CHEN J, et al, Experimental study and kinetic analysis of the impact of ammonia co-firing ratio on products formation characteristics in ammonia/coal co-firing process[J]. Fuel, 2022, 329:125496.

ABDALLA A M, HOSSAIN S, NISFINDY O B, et al.Hydrogen production, storage, transportation and key challenges with applications:a review[J]. Energy Conversion and Management, 2018, 165:602-627.

CHAI W S, BAO Y, JIN P, et al. A review on ammonia,ammonia-hydrogen and ammonia-methane fuels[J].Renewable and Sustainable Energy Reviews, 2021,147(39):111254.

KOBAYASHI H, HAYAKAWA A, SOMARATHNE K D,et al. Science and technology of ammonia combustion[J].Proceedings of the Combustion Institute, 2018, 37(1):109-133.

FANG J, XIONG C H, FENG M Q, et al. Utilization of carbon-based energy as raw material instead of fuel with low CO2 emissions:energy analyses and process integration of chemical looping ammonia generation[J].Applied Energy, 2022, 312:118809.

XIA Y, HADI K, HASHIMOTO G, et al. Effect of ammonia/oxygen/nitrogen equivalence ratio on spherical turbulent flame propagation of pulverized coal/ammonia co-combustion[J]. Proceedings of the Combustion Institute, 2021, 38:4043-4052.

XU Y S, WANG H K, LIU X W, et al. Mitigating CO2emission in pulverized coal-fired power plant via co-firing ammonia:a simulation study of flue gas streams and energy efficiency[J]. Energy Conversion and Management, 2022, 256:115328.

杨澜,王勇,汪鑫,等.煤粉掺氢燃烧技术试验研究[J].工业安全与环保, 2025, 51(1):104-108.YANG Lan, WANG Yong, WANG Xin, et al. Study on combustion technology of pulverized coal mixed with hydrogen[J]. Industrial Safety and Environmental Protection, 2025, 51(1):104-108.

田舒嫚,李宇航,张普选,等.燃煤电站锅炉掺氨NOx生成特性研究进展[J].热力发电, 2025, 54(4):1-12.TIAN Shuman, LI Yuhang, ZHANG Puxuan, et al.Research progress on NOx formation characteristics of coal-fired power plant boilers with ammonia injection[J].Thermal Power Generation, 2025, 54(4):1-12.

WANG Z C, JIA Z X, ZHAO C, et al. Effect of ammonia on the characteristics of coal combustion[J]. Journal of the Energy Institute, 2023, 109:101275.

刘鑫,任建兴,李芳芹,等.燃煤锅炉一次风掺混氢氧对炉膛温度影响的数值模拟[J].热能动力工程, 2023,38(1):156-163.LIU Xin, REN Jianxing, LI Fangqin, et al. Numerical simulation of effect of primary air mixed with hydrogen and oxygen on furnace temperature of coal-fired boiler[J].Journal of Engineering for Thermal Energy and Power,2023, 38(1):156-163.

张波,张国军,张向宇,等.煤粉燃烧高温还原区喷氨脱硝技术计算模型开发与一维炉实验验证[J].热力发电, 2021, 50(11):68-74.ZHANG Bo, ZHANG Guojun, ZHANG Xiangyu, et al.Calculation model development and one-dimensional furnace experimental verification of ammonia injection denitration technology in high temperature reduction zone of pulverized coal combustion[J]. Thermal Power Generation, 2021, 50(11):68-74.

浏览量

394

下载量

CSCD

文章被引用时，请邮件提醒。

提交

关联资源

基于增强灰狼优化LSTM神经网络的火电机组SCR脱硝反应器建模

300 MW燃煤锅炉掺烧氢气/氧气数值模拟

燃煤电站锅炉掺氨燃烧特性及对锅炉影响研究进展

小型循环流化床锅炉NOx超低排放改造试验

烟气再循环对燃烧过程NO生成的作用机理研究